Rockwell-automation AutoMax ControlNet Communication Interface Module Bedienungsanleitung

Rockwell Automation AutoMax ControlNet Communication Interface Module (Cat. No. O-58820-2) Major Rev. 2 User Manual

Page 10 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Getting Support Refer to page 79 for information on how to obt

AutoMax ControlNet Module Page 11 Publication number DSMBCN-UM001B-EN-P February 2003 MBCN AutoMax ControlNet Module Overview This chapter contains

Page 12 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 The MBCN can send unscheduled messages to other nodes on the n

AutoMax ControlNet Module Page 13 Publication number DSMBCN-UM001B-EN-P February 2003 Hardware Features MBCNO-58820FaultCodeOKMAC ID101Config NAPC

Page 14 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 OK LED The MBCN contains a hardware watchdog that monitors ope

AutoMax ControlNet Module Page 15 Publication number DSMBCN-UM001B-EN-P February 2003 NAP Port The MBCN has a standard ControlNet NAP port to allow

Page 16 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 The LEDs do not reflect the state of the NAP port. If you conn

AutoMax ControlNet Module Page 17 Publication number DSMBCN-UM001B-EN-P February 2003 Value Meaning C Communication error d One or more connecti

Page 18 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Communication Error The following are common causes for commun

AutoMax ControlNet Module Page 19 Publication number DSMBCN-UM001B-EN-P February 2003 Installation Prevent Electrostatic Discharge The MBCN is sensi

Page 2 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Important User Information Solid state equipment has operation

Page 20 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Installation and Wiring DANGER The user is responsible for co

AutoMax ControlNet Module Page 21 Publication number DSMBCN-UM001B-EN-P February 2003 Step 4. Set the MBCN’s address on the network using the thumb

Page 22 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Quick Start The following steps describe the procedure for usi

AutoMax ControlNet Module Page 23 Publication number DSMBCN-UM001B-EN-P February 2003 Programming the MBCN This section is a guide for configuring a

Page 24 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 AutoMax Registers Description 9478 Link timeout 15362-15614 S

AutoMax ControlNet Module Page 25 Publication number DSMBCN-UM001B-EN-P February 2003 8. To create a connection to another device, right click on t

Page 26 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Creating Connections to Analog I/O Modules Note: You must alwa

AutoMax ControlNet Module Page 27 Publication number DSMBCN-UM001B-EN-P February 2003 not occupied by discrete modules. For example, if the highest

Page 28 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 3. Set the Requested Packet Interval to the desired update rat

AutoMax ControlNet Module Page 29 Publication number DSMBCN-UM001B-EN-P February 2003 3. Set the Connection Name to Consume Data From. 4. RSNetWorx

Page 30 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 8. For the Data Type, select the user-defined data type you cr

AutoMax ControlNet Module Page 31 Publication number DSMBCN-UM001B-EN-P February 2003 10. Set the Node to the MBCN address on the ControlNet networ

Page 32 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 5. RSNetWorx assigns the Input Address, Output Address and St

AutoMax ControlNet Module Page 33 Publication number DSMBCN-UM001B-EN-P February 2003 There is usually some header information included with the dat

Page 34 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 0200 IF NAMSTATE% = 12 THEN GOTO 300 \!ATTACHED0210 DELAY 1 TI

AutoMax ControlNet Module Page 35 Publication number DSMBCN-UM001B-EN-P February 2003 Monitoring Module Operation There are various registers on the

Page 36 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 General Status, hex Extended Status, hex Explanation 01 0115

AutoMax ControlNet Module Page 37 Publication number DSMBCN-UM001B-EN-P February 2003 General Status, hex Extended Status, hex Explanation 03* n/a

Page 38 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 General Status, hex Extended Status, hex Explanation 15 n/a

AutoMax ControlNet Module Page 39 Publication number DSMBCN-UM001B-EN-P February 2003 If bit 3 is set, one or more originator instances does not hav

INTRODUCTION 9 Who Should Use This Manual? 9 Purpose of this Manual 9 Conventions Used in this Manual 9 Getting Support 10 Reference Documents

Page 40 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 AutoMax Registers Name Description 15755 AdapState Current

AutoMax ControlNet Module Page 41 Publication number DSMBCN-UM001B-EN-P February 2003 Unscheduled Messaging The MBCN supports unscheduled messaging

Page 42 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 R/W Register Description R/W 22 Response Poll period, in

AutoMax ControlNet Module Page 43 Publication number DSMBCN-UM001B-EN-P February 2003 The format for the IODEF statement (used only in V2.1 and earl

Page 44 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Application Programming Read and write commands from the MBCN

AutoMax ControlNet Module Page 45 Publication number DSMBCN-UM001B-EN-P February 2003 NOTE: If more than four tasks try to initiate messages at the

Page 46 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Commands Initiated by the Module The commands described in fig

AutoMax ControlNet Module Page 47 Publication number DSMBCN-UM001B-EN-P February 2003 Command 4, Word Range Write, transfers a block of data from th

Page 48 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 20 LOCAL DST% \! The address of the destination node &on t

AutoMax ControlNet Module Page 49 Publication number DSMBCN-UM001B-EN-P February 2003 module to be read from20 LOCAL DST% \! The address of the dest

AutoMax ControlNet Module Page 5 Publication number DSMBCN-UM001B-EN-P February 2003 Memory Overview 23 Configuring Scheduled Connections 24 Creat

Page 50 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 module to be read from20 LOCAL DST% \! The address of the dest

AutoMax ControlNet Module Page 51 Publication number DSMBCN-UM001B-EN-P February 2003 20 LOCAL DST% \! The address of the destination node &on t

Page 52 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Code, hex Description 11 Destination memory full, cannot ac

AutoMax ControlNet Module Page 53 Publication number DSMBCN-UM001B-EN-P February 2003 Extended Status (EXT_STS) Codes for Command 0F If the value i

Page 54 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Code, hex Description 16 Scanner not able to communicate wit

AutoMax ControlNet Module Page 55 Publication number DSMBCN-UM001B-EN-P February 2003 Basic Command Set Commands Command Function Description 02

Page 56 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Differences from the M/N 57C442 Module Interface If you are mo

AutoMax ControlNet Module Page 57 Publication number DSMBCN-UM001B-EN-P February 2003 Viewing Network Parameters The network parameters include the

Page 58 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Name Register Description CurTuiUniqueID 9314-9315 Keeper CR

AutoMax ControlNet Module Page 59 Publication number DSMBCN-UM001B-EN-P February 2003 Name Register Description PndTuiStatus 9292 TUI Status tha

Page 6 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Standard ControlNet Counters 64 Module Specific Counters 65 T

Page 60 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 State Registers The MBCN maintains several registers that indi

AutoMax ControlNet Module Page 61 Publication number DSMBCN-UM001B-EN-P February 2003 Name Value Meaning NAM_SEND_ALIVE 07h Transitional state in

Page 62 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Name Value 7-Segment LED KPR_STE_NET_CHANGE_FAULTED_MASTER 1

AutoMax ControlNet Module Page 63 Publication number DSMBCN-UM001B-EN-P February 2003 Channel State The Channel State register (9247) shows the stat

Page 64 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Diagnostic Counters The MBCN maintains two sets of diagnostic

AutoMax ControlNet Module Page 65 Publication number DSMBCN-UM001B-EN-P February 2003 Name Location Description with the network, configured lengt

Page 66 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Name Location Description ReplySentOk 9385 High Level Repl

AutoMax ControlNet Module Page 67 Publication number DSMBCN-UM001B-EN-P February 2003 Active Node List The MBCN maintains a list of active nodes on

Page 68 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 ID Area The ID area contains information that identifies the M

AutoMax ControlNet Module Page 69 Publication number DSMBCN-UM001B-EN-P February 2003 7 6 5 4 Description 0 0 0 0 Self test 0 0 0 1 Firmware up

AutoMax ControlNet Module Page 7 Publication number DSMBCN-UM001B-EN-P February 2003 Table of Figures Figure 1 Serial Cable Wiring...

Page 70 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Current Address Register 9244 contains the value read from the

AutoMax ControlNet Module Page 71 Publication number DSMBCN-UM001B-EN-P February 2003 Firmware Version Information The MBCN firmware consists of two

Page 72 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Using the Host Watchdog The host watchdog is a feature you can

AutoMax ControlNet Module Page 73 Publication number DSMBCN-UM001B-EN-P February 2003 Updating the Firmware You can update the firmware on the MBCN

Page 74 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 2. When the AutoMax is powering up, the 7-segment LED flashes

AutoMax ControlNet Module Page 75 Publication number DSMBCN-UM001B-EN-P February 2003 PGA Config Write Successful**** Cycle Power ****5. Cycle powe

Page 76 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Converting from Major Revision 1 to 2 If you have a network co

AutoMax ControlNet Module Page 77 Publication number DSMBCN-UM001B-EN-P February 2003 6. Select Device > Scanlist Configuration. Notice that the

Page 78 AutoMax ControlNet Module Publication number DSMBCN-UM001B-EN-P February 2003 Specifications The MBCN is a standard AutoMax module with the

AutoMax ControlNet Module Page 79 Publication number DSMBCN-UM001B-EN-P February 2003 Support Local Drive Solutions Contact Directory New England

www.rockwellautomation.com Corporate Headquarters Rockwell Automation, 777 East Wisconsin Avenue, Suite 1400, Milwaukee, WI, 532

Introduction This introduction covers the following topics: • who should use this manual • the purpose of the manual • contents of the manual •